Lenovo ThinkPad T60 Hardware Maintenance Manual

Lenovo Desktop, Keyboard THINKPAD T60 - Hardware maintenance manual Free PDF Download on Guides-Base.com

Lenovo THINKPAD T60 - Desktop, Keyboard PDF Hardware maintenance manual

  • Model: THINKPAD T60 -
  • Brand: Lenovo
  • Type: Hardware maintenance manual
  • Category: Desktop, Keyboard
  • File Size:
  • No. of pages: 158
Download Lenovo THINKPAD T60 - PDF Manual

Also for Lenovo THINKPAD T60 -:

Lenovo THINKPAD T60 - Summary of Contents:

Page view Summary of Page's Content
1 Page 1 of Lenovo THINKPAD T60 - Hardware maintenance manual

Lenovo THINKPAD T60 - Hardware maintenance manual ThinkPad ® T60 and T60p (15.4-inch wi d escree n ) Hard ware Maintenance Manual October 2007 This manual supports: ThinkPad T60 and T60p (15.4-inch widescreen) (MT 6369, 6370, 6371, 6372, 8741, 8742, 8743, and 8744) (...)

2 Page 2 of Lenovo THINKPAD T60 - Hardware maintenance manual

Lenovo THINKPAD T60 - Manual (...)

3 Page 3 of Lenovo THINKPAD T60 - Hardware maintenance manual

Lenovo THINKPAD T60 - Manual ThinkPad ® T60 and T60p (15.4-inch wi d escree n ) Hard ware Maintenance Manual (...)

4 Page 4 of Lenovo THINKPAD T60 - Hardware maintenance manual

THINKPAD T60 - Note Before using this information and the product it supports, be sure to read the general information under “Notices” on page 149. Third Edition (October 2007) © Copyright Lenovo 2006, 2007. All rights reserved. LENOVO products, data, computer software, and services have been developed exclusively at private expense and are sold to governmental entities as commercial items a (...)

5 Page 5 of Lenovo THINKPAD T60 - Hardware maintenance manual

THINKPAD T60 - Contents About this manual . . . . . . . . . .1 Introduction . . . . . . . . . . . . .3 Important service information . . . . . . . .3 Strategy for replacing FRUs . . . . . . . . .3 Strategy for replacing a hard disk drive . . . .4 Important notice for replacing a system board . .4 How to use error messages . . . . . . . .4 Strategy for replaci (...)

6 Page 6 of Lenovo THINKPAD T60 - Hardware maintenance manual

Lenovo THINKPAD T60 - Manual iv MT 6369, 6370, 6371, 6372, 8741, 8742, 8743, and 8744 (...)

7 Page 7 of Lenovo THINKPAD T60 - Hardware maintenance manual

THINKPAD T60 - About this manual This manual contains service and reference information for ThinkPad ® T60 and T60p (15.4-inch widescreen) (MT 6369, 6370, 6371, 6372, 8741, 8742, 8743, and 8744) products. Use this manual along with the advanced diagnostic tests to troubleshoot problems. The manual is divided into sections as follows: v The common sections provide general information, guidelines (...)

8 Page 8 of Lenovo THINKPAD T60 - Hardware maintenance manual

Lenovo THINKPAD T60 - Desktop, Keyboard Manual 2 MT 6369, 6370, 6371, 6372, 8741, 8742, 8743, and 8744 (...)

9 Page 9 of Lenovo THINKPAD T60 - Hardware maintenance manual

THINKPAD T60 - Introduction Important service information Important BIOS and device driver fixes are customer-installable. The BIOS and device drivers are posted on the customer support site http://www.lenovo.com/ support Advise customers to contact the Customer Support Center at 800-426-7378 if they need assistance in obtaining or installing any software fixes, drivers, and BIOS downloads. Customer (...)

10 Page 10 of Lenovo THINKPAD T60 - Hardware maintenance manual

Lenovo THINKPAD T60 - Desktop, Keyboard Manual Attention: The setup configuration on the computer you are servicing may have been customized. Running Automatic Configuration may alter the settings. Note the current configuration settings (using the View Configuration option); then, when service has been completed, verify that those settings remain in effect. Strategy for replacing a hard disk drive Always try to run a low-leve (...)

11 Page 11 of Lenovo THINKPAD T60 - Hardware maintenance manual

Lenovo THINKPAD T60 - Manual v The PEW record is the 4-digit MT and 3-digit model, where model = “CTO” (Example: 1829-CTO). v eSupport will show both the CTO and CMV machine type models (Example: 1829-CTO and 1829-W15 will be found on the eSupport site.) v The HMM will have the 4-digit MT and 3-digit CTO model only (Example: 1829-CTO). Again, CMVs are custom models and are not found in the (...)

12 Page 12 of Lenovo THINKPAD T60 - Hardware maintenance manual

Lenovo THINKPAD T60 - Hardware maintenance manual For the Remaining FRUs (the complete list of FRUs at the MT Model level) v eSupport can be used to view the complete list of FRUs for a machine type and model. v To view the complete list of FRUs, type in the machine type and model (Example: 1829-CTO) under QUICK PATH. Under “View by Document Type” select PARTS INFORMATION. Under “Filter by Category” select SER (...)

13 Page 13 of Lenovo THINKPAD T60 - Hardware maintenance manual

Lenovo THINKPAD T60 - Desktop, Keyboard Manual Diskette compatibility matrix The compatibility of each of the drives with the diskettes for it is as follows: Diskette drive Diskette capacity Compatibility 3.5-inch 1.0 MB Read and write 2.0 MB Read and write 4.0 MB Not compatible Safety notices: multilingual translations In this manual, safety notices appear in English with a page number reference to the appropriate multilin (...)

14 Page 14 of Lenovo THINKPAD T60 - Hardware maintenance manual

Lenovo THINKPAD T60 - Hardware maintenance manual Safety notice 2 DANGER Some standby batteries contain a small amount of nickel and cadmium. Do not disassemble a standby battery, recharge it, throw it into fire or water, or short-circuit it. Dispose of the battery as required by local ordinances or regulations. Use only the battery in the appropriate parts listing. Use of an incorrect battery can result in ignition o (...)

15 Page 15 of Lenovo THINKPAD T60 - Hardware maintenance manual

Lenovo THINKPAD T60 - Desktop, Keyboard Manual Safety notice 3 DANGER The battery pack contains small amounts of nickel. Do not disassemble it, throw it into fire or water, or short-circuit it. Dispose of the battery pack as required by local ordinances or regulations. Use only the battery in the appropriate parts listing when replacing the battery pack. Use of an incorrect battery can result in ignition or explosi (...)

16 Page 16 of Lenovo THINKPAD T60 - Hardware maintenance manual

Lenovo THINKPAD T60 - Desktop, Keyboard Manual Safety notice 4 DANGER The lithium battery can cause a fire, an explosion, or a severe burn. Do not recharge it, remove its polarized connector, disassemble it, heat it above 100°C (212°F), incinerate it, or expose its cell contents to water. Dispose of the battery as required by local ordinances or regulations. Use only the battery in the appropriate parts listing. (...)

17 Page 17 of Lenovo THINKPAD T60 - Hardware maintenance manual

Lenovo THINKPAD T60 - Hardware maintenance manual Safety notice 5 Safety notice 6 DANGER If the LCD breaks and the fluid from inside the LCD gets into your eyes or on your hands, immediately wash the affected areas with water for at least 15 minutes. Seek medical care if any symptoms from the fluid are present after washing. Si le panneau d’affichage à cristaux liquides se brise et que vous recevez dans les (...)

18 Page 18 of Lenovo THINKPAD T60 - Hardware maintenance manual

THINKPAD T60 - Safety notice 7 DANGER Safety notice 8 DANGER Though the main batteries have low voltage, a shorted or grounded battery can produce enough current to burn personnel or combustible materials. Bien que le voltage des batteries principales soit peu élevé, le court-circuit ou la mise à la masse d’une batterie peut produire suffisamment de courant pour brûler des (...)

19 Page 19 of Lenovo THINKPAD T60 - Hardware maintenance manual

Lenovo THINKPAD T60 - Desktop, Keyboard Manual Safety information The following section presents safety information with which you need to be familiar before you service a ThinkPad computer. General safety Follow these rules to ensure general safety: v Observe good housekeeping in the area of the machines during and after maintenance. v When lifting any heavy object: 1. Make sure that you can stand safely without slipp (...)

20 Page 20 of Lenovo THINKPAD T60 - Hardware maintenance manual

Lenovo THINKPAD T60 - Manual Important Use only approved tools and test equipment. Some hand tools have handles covered with a soft material that does not insulate you when working with live electrical currents. Many customers have, near their equipment, rubber floor mats that contain small conductive fibers to decrease electrostatic discharges. Do not use this type of mat to protect yourself from electrical (...)

21 Page 21 of Lenovo THINKPAD T60 - Hardware maintenance manual

Lenovo THINKPAD T60 - Desktop, Keyboard Manual v Do not service the following parts with the power on when they are removed from their normal operating places in a machine: – Power supply units – Pumps – Blowers and fans – Motor generators and similar units. (This practice ensures correct grounding of the units.) v If an electrical accident occurs: – Use caution; do not become a victim yourself. – (...)

22 Page 22 of Lenovo THINKPAD T60 - Hardware maintenance manual

Lenovo THINKPAD T60 - Hardware maintenance manual 9. Check that the power-supply cover fasteners (screws or rivets) have not been removed or tampered with. Handling devices that are sensitive to electrostatic discharge Any computer part containing transistors or integrated circuits (ICs) should be considered sensitive to electrostatic discharge (ESD.) ESD damage can occur when there is a difference in charge between objects. Prote (...)

23 Page 23 of Lenovo THINKPAD T60 - Hardware maintenance manual

Lenovo THINKPAD T60 - Hardware maintenance manual Laser compliance statement Some models of ThinkPad computer are equipped from the factory with an optical storage device such as a CD-ROM drive or a DVD-ROM drive. Such devices are also sold separately as options. If one of these drives is installed, it is certified in the U.S. to conform to the requirements of the Department of Health and Human Services 21 Code of Federal (...)

24 Page 24 of Lenovo THINKPAD T60 - Hardware maintenance manual

Lenovo THINKPAD T60 - Desktop, Keyboard Manual A CD-ROM drive, a DVD-ROM drive, or any other storage device installed may contain an embedded Class 3A or Class 3B laser diode. Note the following: DANGER Emits visible and invisible laser radiation when open. Do not stare into the beam, do not view directly with optical instruments, and avoid direct exposure to the beam. Radiação por raio laser ao abrir. Não olhe (...)

25 Page 25 of Lenovo THINKPAD T60 - Hardware maintenance manual

Lenovo THINKPAD T60 - Desktop, Keyboard Manual General descriptions The descriptions in this chapter apply to any ThinkPad model that has the PC-Doctor ® for DOS diagnostics program. Some descriptions might not apply to your particular computer. Read this first Before you go to the checkout guide, be sure to read this section. Important notes v Only certified trained personnel should service the computer. v Before re (...)

26 Page 26 of Lenovo THINKPAD T60 - Hardware maintenance manual

Lenovo THINKPAD T60 - Hardware maintenance manual Following is a list of some common items that are not covered under warranty and some symptoms that might indicate that the system was subjected to stress beyond normal use. Before checking problems with the computer, determine whether the damage is covered under the warranty by referring to the following list: The following are not covered under warranty: v LCD panel cracke (...)

27 Page 27 of Lenovo THINKPAD T60 - Hardware maintenance manual

Lenovo THINKPAD T60 - Hardware maintenance manual Related service information This section provides information about the following: v “Service Web site” v “Restoring the factory contents by using Product Recovery discs” v “Passwords” on page 22 v “Power management” on page 24 Service Web site When the latest maintenance diskette and the system program service diskette become available, they will be posted on (...)

28 Page 28 of Lenovo THINKPAD T60 - Hardware maintenance manual

THINKPAD T60 - A total progress bar allows you to audit this process, which will take about 8 minutes. The final recovery disc may be safely removed during this time, but may also be left in the optical drive since it is not bootable. 7. You will then be prompted to restart the computer. Select Yes. A warning window appears, giving you one last chance to stop the restart, but disappe (...)

29 Page 29 of Lenovo THINKPAD T60 - Hardware maintenance manual

THINKPAD T60 - Attention: If the user HDP has been forgotten, check whether a master HDP has been set. If it has, it can be used for access to the hard disk drive. If no master HDP is available, neither Lenovo nor Lenovo authorized servicers provide any services to reset either the user or the master HDP, or to recover data from the hard disk drive. The hard disk drive can be replac (...)

30 Page 30 of Lenovo THINKPAD T60 - Hardware maintenance manual

Lenovo THINKPAD T60 - Manual How to remove the hard-disk password Attention: If User only mode is selected and the user HDP has been forgotten and cannot be made available to the servicer, neither Lenovo nor Lenovo authorized servicers provide any services to reset the user HDPs or to recover data from the hard disk drive. The hard disk drive can be replaced for a scheduled fee. To remove a user HDP (...)

31 Page 31 of Lenovo THINKPAD T60 - Hardware maintenance manual

Lenovo THINKPAD T60 - Desktop, Keyboard Manual To enter standby mode, press Fn+F4. Note: If you are using the ACPI operating system, you can change the action of Fn+F4. In certain circumstances, the computer goes into standby mode automatically: v If a “suspend time” has been set on the timer, and the user does not do any operation with the keyboard, the TrackPoint ® , the hard disk, the parallel connector, or th (...)

32 Page 32 of Lenovo THINKPAD T60 - Hardware maintenance manual

Lenovo THINKPAD T60 - Manual v If you are using the APM operating system and have set the mode to Power switch mode [Hibernation], turn off the power switch. v If you are using the ACPI operating system and have defined one of the following actions as the event that causes the system to go into hibernation mode, perform that action. – Closing the lid. – Pressing the power button. – Pr (...)

33 Page 33 of Lenovo THINKPAD T60 - Hardware maintenance manual

Lenovo THINKPAD T60 - Manual Checkout guide Use the following procedures as a guide in identifying and correcting problems with the ThinkPad computer. Note: The diagnostic tests are intended to test only ThinkPad products. The use of non-ThinkPad products, prototype cards, or modified options can lead to false indications of errors and invalid system responses. 1. Identify the failing symptoms in as much (...)

34 Page 34 of Lenovo THINKPAD T60 - Hardware maintenance manual

Lenovo THINKPAD T60 - Desktop, Keyboard Manual To run the test, do as follows: Note: In the following procedure, you can select an item not only with the arrow keys, but also with the TrackPoint pointer. Instead of pressing Enter, click the left button. 1. Insert the PC-Doctor disk into the diskette drive; then power on the computer. If the computer cannot be powered on, go to “Power system checkout” on page 30, (...)

35 Page 35 of Lenovo THINKPAD T60 - Hardware maintenance manual

THINKPAD T60 - The options on the test menu are as follows: Diagnostics Interactive Tests v Run Normal Test v Run Quick Test v CPU/Coprocessor v Systemboard v Video Adapter v Serial Ports v Parallel Ports v Fixed Disks v Diskette Drives v Other Devices v ThinkPad Devices v Communication v Wireless LAN v Memory Test – Full v Memory Test – Quick v Keyboard (...)

36 Page 36 of Lenovo THINKPAD T60 - Hardware maintenance manual

Lenovo THINKPAD T60 - Manual Utility v Run External Tests v Surface Scan Hard Disk v Benchmark System v DOS Shell v Tech Support Form v Battery Rundown v View Test Log v Print Log v Save Log v Full Erase Hard Drive v Quick Erase Hard Drive PC-Doctor for Windows This product is designed to help you troubleshoot and resolve problems related to your computer. Select one of the catego (...)

37 Page 37 of Lenovo THINKPAD T60 - Hardware maintenance manual

Lenovo THINKPAD T60 - Desktop, Keyboard Manual 1 2 3 (20V) Pin Voltage (V dc) 1 +20 2 0 3 Ground Note: Output voltage of pin no.2 of the ac adapter may different from the one you are servicing. 3. If the voltage is not correct, replace the ac adapter. 4. If the voltage is acceptable, do the following: v Replace the system board. v If the problem persists, go to “Product overview” on page 34. Note: Noi (...)

38 Page 38 of Lenovo THINKPAD T60 - Hardware maintenance manual

Lenovo THINKPAD T60 - Desktop, Keyboard Manual 1(+) 2(+) 3 4 5 6(-) 7(-) Terminal Voltage (V dc) 1 + 0 to + 12.6 7 Ground (−) 3. If the voltage is less than +11.0 V dc, the battery pack has been discharged. Note: Recharging will take at least 3 hours, even if the indicator does not turn on. If the voltage is still less than +11.0 V dc after recharging, replace the battery. 4. If the voltage is more than +11 (...)

39 Page 39 of Lenovo THINKPAD T60 - Hardware maintenance manual

Lenovo THINKPAD T60 - Desktop, Keyboard Manual ThinkPad T60 and T60p (15.4-inch widescreen) Product overview . . . . . . . . . . . .34 Specifications . . . . . . . . . . . . .34 Status indicators . . . . . . . . . . . .37 FRU tests . . . . . . . . . . . . . .40 Fn key combinations . . . . . . . . . .42 Symptom-to-FRU index . . . . . . . . . .45 Numeric error codes . . . . . . . . (...)

40 Page 40 of Lenovo THINKPAD T60 - Hardware maintenance manual

Lenovo THINKPAD T60 - Hardware maintenance manual Product overview This section presents the following product-unique information: v “Specifications” v “Status indicators” on page 37 v “FRU tests” on page 40 v “Fn key combinations” on page 42 Specifications The following table lists the specifications of the ThinkPad T60 and T60p (15.4-inch widescreen): Feature Description Processor v Intel ® Core ™ 2 Du (...)

41 Page 41 of Lenovo THINKPAD T60 - Hardware maintenance manual

Lenovo THINKPAD T60 - Hardware maintenance manual Feature Description CMOS RAM v 242 bytes Hard disk drive v 40 GB, 5400 rpm, 9.5 mm high, Serial ATA (SATA) interface v 60 GB, 5400 rpm, 9.5 mm high, SATA interface v 80 GB, 5400 rpm, 9.5 mm high, SATA interface v 100 GB, 5400 rpm, 9.5 mm high, SATA interface v 120 GB, 5400 rpm, 9.5 mm high, SATA interface v 100 GB, 7200 rpm, 9.5 mm high, SATA interface (...)

42 Page 42 of Lenovo THINKPAD T60 - Hardware maintenance manual

Lenovo THINKPAD T60 - Desktop, Keyboard Manual Feature Description Touch pad v UltraNav ® ThinkLight ® Yes Battery v Li-ion battery (6 cells) 5.2 Ah v Li-ion battery (9 cells) 7.8 Ah v Ultrabay Slim Li Polymer battery (3 cells) (option) AC adapter v 65-watt type v 90-watt type Preinstalled operating system v Windows XP Professional v Windows XP Home Edition v Windows Vista TM Home Basic (32 bit) v Wind (...)

43 Page 43 of Lenovo THINKPAD T60 - Hardware maintenance manual

THINKPAD T60 - Status indicators The system status indicators show the status of the computer, as follows: 1 2 3 4 5 6 7 8 9 10 11 8910 Product overview ThinkPad T60 and T60p (15.4-inch widescreen) 37 (...)

44 Page 44 of Lenovo THINKPAD T60 - Hardware maintenance manual

THINKPAD T60 - Indicator Meaning 1 Wireless status Green: The wireless feature (the IEEE 802.11 standard or IEEE 802.11n) is on, and the radio link is ready for use. Blinking green: Data is being transmitted. 2 Bluetooth status R Green: Bluetooth wireless is operational. This indicator is on when Bluetooth wireless is on and not in suspend mode. 3 Wireless WAN status Green: (...)

45 Page 45 of Lenovo THINKPAD T60 - Hardware maintenance manual

Lenovo THINKPAD T60 - Manual Indicator Meaning 9 AC power status Green: The computer is connected to the ac power supply. 10 Standby status Green: The computer is in standby mode. Blinking green: The computer is entering standby mode or hibernation mode, or is resuming normal operation. 11 Ultrabay Slim status Green: An Ultrabay Slim device is installed and in use. Blinking green: An Ult (...)

46 Page 46 of Lenovo THINKPAD T60 - Hardware maintenance manual

Lenovo THINKPAD T60 - Hardware maintenance manual FRU tests The following table shows the test for each FRU. FRU Applicable test System board 1. Diagnostics --> CPU/Coprocessor 2. Diagnostics --> Systemboard 3. If the ThinkPad Advanced Dock, the ThinkPad Advanced Mini Dock or the ThinkPad Essential Port Replicator is attached to the ThinkPad computer, detach it. Place the computer on a horizontal surface, and run D (...)

47 Page 47 of Lenovo THINKPAD T60 - Hardware maintenance manual

Lenovo THINKPAD T60 - Desktop, Keyboard Manual FRU Applicable test Diskette drive 1. Diagnostics --> Diskette Drives 2. Interactive Tests --> Diskette DVD drive or DVD/CD-RW combo drive 1. Diagnostics --> Other Devices --> CD-ROM/DVD 2. Interactive Tests --> CD-ROM/DVD Test Memory 1. If two DIMMs are installed, remove one of them and run Diagnostics --> Memory Test—Quick. 2. If the problem does n (...)

48 Page 48 of Lenovo THINKPAD T60 - Hardware maintenance manual

Lenovo THINKPAD T60 - Desktop, Keyboard Manual Fn key combinations The following table shows the function of each combination of Fn with a function key. Key combination Description Fn+F1 Reserved. Fn+F2 Reserved. Fn+F3 Select a power scheme that has been created by Power Manager. When you press this combination, a panel for selecting a power scheme appears. Notes: 1. To use the Fn+F3 key combination, you must have the (...)

49 Page 49 of Lenovo THINKPAD T60 - Hardware maintenance manual

Lenovo THINKPAD T60 - Hardware maintenance manual Key combination Description Fn+F7 Apply a presentation scheme directly, with no need to start Presentation Director. To disable this function and use the Fn+F7 key combination for switching a display output location, start Presentation Director, and change the settings. Switch a display output location v External monitor (CRT display) v Computer display and external monitor (LCD (...)

50 Page 50 of Lenovo THINKPAD T60 - Hardware maintenance manual

Lenovo THINKPAD T60 - Manual Key combination Description Fn+F10 Reserved. Fn+F11 Reserved. Fn+F12 Put the computer into hibernation mode. To return to normal operation, press the power button for less than four seconds. Note: To use Fn+F12 for hibernation, you must have the ThinkPad PM device driver installed on the computer. Fn+PgUp Turn the ThinkLight on or off. Note: This function is supported only on t (...)

51 Page 51 of Lenovo THINKPAD T60 - Hardware maintenance manual

THINKPAD T60 - Symptom-to-FRU index The symptom-to-FRU index in this section lists symptoms and errors and their possible causes. The most likely cause is listed first, in boldface type. Note: Do the FRU replacement or other actions in the sequence shown in the column headed “FRU or action, in sequence.” If replacing a FRU does not solve the problem, put the original part back in the (...)

52 Page 52 of Lenovo THINKPAD T60 - Hardware maintenance manual

THINKPAD T60 - Symptom or error FRU or action, in sequence 0190 Critical low-battery error 1. Charge the battery pack. 2. Battery pack. 0191 System Security—Invalid Remote Change requested. 1. Run BIOS Setup Utility, and then save current setting by pressing F10. 2. System board. 0192 System Security— Embedded Security hardware tamper detected. System board. 0199 System Security— Securit (...)

53 Page 53 of Lenovo THINKPAD T60 - Hardware maintenance manual

Lenovo THINKPAD T60 - Hardware maintenance manual Symptom or error FRU or action, in sequence 0252 Password checksum bad—The password is cleared. Reset the password by running BIOS Setup Utility. 0260 System timer error. 1. Charge the backup battery for more than 8 hours by connecting the ac adapter. 2. Replace the backup battery and run BIOS Setup Utility to reset the time and date. 3. System board. 0270 Real-time clo (...)

54 Page 54 of Lenovo THINKPAD T60 - Hardware maintenance manual

Lenovo THINKPAD T60 - Manual Symptom or error FRU or action, in sequence 2000 Hard Drive Active Protection sensor diagnostics failed. Press <Esc> to continue. Press <F1> to enter SETUP 1. Undock docking station or port replicator if it is attached to the ThinkPad computer, and place the computer on a horizontal surface. Do not apply any physical shock to the computer. 2. Run Diagnostics --> (...)

55 Page 55 of Lenovo THINKPAD T60 - Hardware maintenance manual

Lenovo THINKPAD T60 - Hardware maintenance manual Error messages Symptom or error FRU or action, in sequence Device address conflict. 1. Load “Setup Defaults” in the BIOS Setup Utility. 2. Backup battery. 3. System board. Allocation error for device. 1. Load “Setup Defaults” in the BIOS Setup Utility. 2. Backup battery. 3. System board. Failing bits: nnnn. 1. DIMM. 2. System board. Invalid system configu (...)

56 Page 56 of Lenovo THINKPAD T60 - Hardware maintenance manual

Lenovo THINKPAD T60 - Manual Beep symptoms Symptom or error FRU or action, in sequence One beep and a blank, unreadable, or flashing LCD. 1. Reseat the LCD connector. 2. LCD assembly. 3. External CRT. 4. System board. One long and two short beeps, and a blank or unreadable LCD. 1. System board. 2. LCD assembly. 3. DIMM. Two short beeps with error codes. POST error. See “Numeric error (...)

57 Page 57 of Lenovo THINKPAD T60 - Hardware maintenance manual

Lenovo THINKPAD T60 - Desktop, Keyboard Manual LCD-related symptoms Important: The TFT LCD for the notebook computer contains many thin-film transistors (TFTs). The presence of a small number of dots that are missing, discolored, or always lighted is characteristic of TFT LCD technology, but excessive pixel problems can cause viewing concerns. The LCD should be replaced if the number of missing, discolored, or lighted dots i (...)

58 Page 58 of Lenovo THINKPAD T60 - Hardware maintenance manual

THINKPAD T60 - Intermittent problems Intermittent system hang problems can be due to a variety of causes that have nothing to do with a hardware defect, such as cosmic radiation, electrostatic discharge, or software errors. FRU replacement should be considered only when a problem recurs. When analyzing an intermittent problem, do the following: 1. Run the diagnostic test for the system board (...)

59 Page 59 of Lenovo THINKPAD T60 - Hardware maintenance manual

THINKPAD T60 - FRU replacement notices This section contains notices related to removing and replacing parts. Read this section carefully before replacing any FRU. Screw notices Loose screws can cause a reliability problem. In the ThinkPad computer, this problem is addressed with special nylon-coated screws that have the following characteristics: v They maintain tight connections. v They do n (...)

60 Page 60 of Lenovo THINKPAD T60 - Hardware maintenance manual

Lenovo THINKPAD T60 - Hardware maintenance manual v “Retaining the UUID” v “Reading or writing the ECA information” Restoring the serial number of the system unit When the computer was manufactured, the EEPROM on the system board was loaded with the serial numbers of the system and all major components. These numbers need to remain the same throughout the life of the computer. If you replace the system board, you (...)

61 Page 61 of Lenovo THINKPAD T60 - Hardware maintenance manual

THINKPAD T60 - To check what ECAs have been previously applied to the machine, use the ECA Information Read/Write function on the ThinkPad Hardware Maintenance Diskette Version 1.73 or later. 1. Insert the ThinkPad Hardware Maintenance Diskette Version 1.73 or later, and restart the computer. 2. From the main menu, select 6. Set ECA Information. 3. To read ECA information, select 2. Read (...)

62 Page 62 of Lenovo THINKPAD T60 - Hardware maintenance manual

Lenovo THINKPAD T60 - Hardware maintenance manual Removing and replacing a FRU This section presents directions and drawings for use in removing and replacing a FRU. Be sure to observe the following general rules: 1. Do not try to service any computer unless you have been trained and certified. An untrained person runs the risk of damaging parts. 2. Before replacing any FRU, review “FRU replacement notices” on page 5 (...)

63 Page 63 of Lenovo THINKPAD T60 - Hardware maintenance manual

Lenovo THINKPAD T60 - Hardware maintenance manual 1010 Battery pack DANGER Unlock the battery release lever 1. Holding the battery release lever in the unlocked position 2, remove the battery pack in the direction shown by arrow 3. 3 1 2 When installing: Install the battery pack along the slide rails of the slot. Then make sure that the battery release lever is in the locked position. Use only t (...)

64 Page 64 of Lenovo THINKPAD T60 - Hardware maintenance manual

Lenovo THINKPAD T60 - Manual 1020 Ultrabay Slim device Note Ultrabay Slim does not accept any of the following devices: v Ultrabay Plus devices v Ultrabay 2000 devices When you release the switch in step 1, the lever pops out. In step 2, pull the lever a little to release the device from the bay. 1 2 3 Removing and replacing a FRU 58 MT 6369, 6370, 6371, 6372, 8741, 87 (...)

65 Page 65 of Lenovo THINKPAD T60 - Hardware maintenance manual

THINKPAD T60 - 1030 Hard disk drive cover, hard disk drive, and hard disk drive rubber rails For access, remove this FRU: v “1010 Battery pack” on page 57 Attention v Do not drop the hard disk drive or apply any physical shock to it. The hard disk drive is sensitive to physical shock. Improper handling can cause damage and permanent loss of data. v Before removing the drive, (...)

66 Page 66 of Lenovo THINKPAD T60 - Hardware maintenance manual

Lenovo THINKPAD T60 - Hardware maintenance manual 3 4 2 When installing: Make sure that the hard disk drive connector is attached firmly. 5 5 When installing: The rubber rails on the hard disk drive must be attached to the replacement drive. Otherwise the drive cannot be installed properly. Removing and replacing a FRU 60 MT 6369, 6370, 6371, 6372, 8741, 8742, 8743, and 8744 (...)

67 Page 67 of Lenovo THINKPAD T60 - Hardware maintenance manual

Lenovo THINKPAD T60 - Manual 1040 Palm rest or palm rest with fingerprint reader For access, remove this FRU in order: v “1010 Battery pack” on page 57 Notes In models with the fingerprint reader, the sensor is attached to the palm rest FRU. If the fingerprint reader has any defects, you can replace it by the procedures given in this section, which are the same for a palm rest with or witho (...)

68 Page 68 of Lenovo THINKPAD T60 - Hardware maintenance manual

Lenovo THINKPAD T60 - Desktop, Keyboard Manual 2 3 Removing and replacing a FRU 62 MT 6369, 6370, 6371, 6372, 8741, 8742, 8743, and 8744 (...)

69 Page 69 of Lenovo THINKPAD T60 - Hardware maintenance manual

Lenovo THINKPAD T60 - Manual When installing: When you attach the palm rest, do as follows: 1. Attach the fingerprint reader connector firmly to the system board. 2. Attach the palm rest so that the two projections of the palm rest (a) firmly fit into the guide holes of the keyboard bezel as shown in this figure. a a 3. Align the front side of the palm rest to the frame, and press t (...)

70 Page 70 of Lenovo THINKPAD T60 - Hardware maintenance manual

Lenovo THINKPAD T60 - Desktop, Keyboard Manual 1050 DIMM For access, remove these FRUs in order: v “1010 Battery pack” on page 57 v “1040 Palm rest or palm rest with fingerprint reader” on page 61 2 1 1 When installing: Insert the notched end of the DIMM into the socket. Press the DIMM firmly, and pivot it until it snaps into the place. Make sure that it is firmly fixed in the slot and does not move (...)

71 Page 71 of Lenovo THINKPAD T60 - Hardware maintenance manual

Lenovo THINKPAD T60 - Manual 1060 Keyboard For access, remove these FRUs in order: v “1010 Battery pack” on page 57 v “1040 Palm rest or palm rest with fingerprint reader” on page 61 1 Step Icon Screw (quantity) Color Torque 1 M2 × 14 mm, flat-head, nylon-coated (1) Black 0.167 Nm (1.7 kgfcm) Lift the keyboard a little in the direction shown by arrow 2, and then detach (...)

72 Page 72 of Lenovo THINKPAD T60 - Hardware maintenance manual

Lenovo THINKPAD T60 - Hardware maintenance manual When installing: Make sure that the keyboard edges a are under the frame as shown in this figure. a a Removing and replacing a FRU 66 MT 6369, 6370, 6371, 6372, 8741, 8742, 8743, and 8744 (...)

73 Page 73 of Lenovo THINKPAD T60 - Hardware maintenance manual

Lenovo THINKPAD T60 - Hardware maintenance manual 1070 Modem daughter card (MDC-1.5) For access, remove these FRUs in order: v “1010 Battery pack” on page 57 v “1040 Palm rest or palm rest with fingerprint reader” on page 61 v “1060 Keyboard” on page 65 2 1 1 Step Screw (quantity) Color Torque 1 M2 × 3 mm, small-head, nylon-coated (2) Silver 0.167 Nm (1.7 kgfcm) In step 2, remove the card (...)

74 Page 74 of Lenovo THINKPAD T60 - Hardware maintenance manual

THINKPAD T60 - Turn the card over 3, and detach the modem connector 4. 3 4 When installing: Make sure that the modem connector and the connector on the underside of the card are attached firmly. Removing and replacing a FRU 68 MT 6369, 6370, 6371, 6372, 8741, 8742, 8743, and 8744 (...)

75 Page 75 of Lenovo THINKPAD T60 - Hardware maintenance manual

Lenovo THINKPAD T60 - Hardware maintenance manual 1080 PCI Express Mini Card for 802.11 a/b/g wireless LAN For access, remove these FRUs in order: v “1010 Battery pack” on page 57 v “1040 Palm rest or palm rest with fingerprint reader” on page 61 v “1060 Keyboard” on page 65 In step 1, unplug the jacks by using the removal tool antenna RF connector (P/N: 08K7159) or pick the connectors with your fi (...)

76 Page 76 of Lenovo THINKPAD T60 - Hardware maintenance manual

Lenovo THINKPAD T60 - Desktop, Keyboard Manual When installing: Plug the gray cable into the jack labeled MAIN on the card, and the black cable into the jack labeled AUX. If the computer you are servicing has three cables, put the white cable in the cable bag in the card slot. After you secured the card, make sure that the antenna cables are routed as shown in the following figure. Removing and replacing a FR (...)

77 Page 77 of Lenovo THINKPAD T60 - Hardware maintenance manual

Lenovo THINKPAD T60 - Hardware maintenance manual 1090 PCI Express Mini Card for 802.11 a/b/g/n wireless LAN For access, remove these FRUs in order: v “1010 Battery pack” on page 57 v “1040 Palm rest or palm rest with fingerprint reader” on page 61 v “1060 Keyboard” on page 65 In step 1, unplug the jacks by using the removal tool antenna RF connector (P/N: 08K7159) or pick the connectors with your (...)

78 Page 78 of Lenovo THINKPAD T60 - Hardware maintenance manual

THINKPAD T60 - When installing: Plug the gray cable (MAIN) into the jack labeled TR1, the white cable (3rd) into jack labeled R0, and the black cable (AUX) into jack labeled TR2 on the card. Removing and replacing a FRU 72 MT 6369, 6370, 6371, 6372, 8741, 8742, 8743, and 8744 (...)

79 Page 79 of Lenovo THINKPAD T60 - Hardware maintenance manual

Lenovo THINKPAD T60 - Hardware maintenance manual 1100 Backup battery DANGER For access, remove these FRUs in order: v “1010 Battery pack” on page 57 v “1040 Palm rest or palm rest with fingerprint reader” on page 61 v “1060 Keyboard” on page 65 2 1 When installing: Make sure that the battery connector is attached firmly. Use only the battery specified in the parts list for your computer. Any o (...)

80 Page 80 of Lenovo THINKPAD T60 - Hardware maintenance manual

Lenovo THINKPAD T60 - Desktop, Keyboard Manual 1110 Keyboard bezel For access, remove these FRUs in order: v “1010 Battery pack” on page 57 v “1040 Palm rest or palm rest with fingerprint reader” on page 61 v “1060 Keyboard” on page 65 1 1 Step Screw (quantity) Color Torque 1 M2 × 14 mm, flat-head, nylon-coated (2) Black 0.167 Nm (1.7 kgfcm) (continued) Removing and replacing a FRU 74 MT 6 (...)

81 Page 81 of Lenovo THINKPAD T60 - Hardware maintenance manual

Lenovo THINKPAD T60 - Manual 5 5 3 2 3 4 4 In step 2, release the wireless antenna cables from the cable guide. Step Screw (quantity) Color Torque 3 M2 × 3 mm, small-head, nylon-coated (2) Silver 0.167 Nm (1.7 kgfcm) 4 M2 × 3.5 mm, flat-head, nylon-coated (2) Black 0.167 Nm (1.7 kgfcm) 5 M2 × 3 mm, small-head, nylon-coated (2) Silver 0.167 Nm (1.7 kgfcm) In step 6, detach (...)

82 Page 82 of Lenovo THINKPAD T60 - Hardware maintenance manual

Lenovo THINKPAD T60 - Manual When installing: 1. Make sure that all the claws are attached firmly. 2. If the computer you are servicing has the wireless WAN antenna cables, route the cables properly as in this figure to prevent them from being pinched by the bezel. 3. Fasten the screws to secure the keyboard bezel. 4. Make sure that the wireless LAN antenna cable that you have released in (...)

83 Page 83 of Lenovo THINKPAD T60 - Hardware maintenance manual

Lenovo THINKPAD T60 - Desktop, Keyboard Manual 1120 PCI Express Mini Card for wireless WAN For access, remove these FRUs in order: v “1010 Battery pack” on page 57 v “1040 Palm rest or palm rest with fingerprint reader” on page 61 v “1060 Keyboard” on page 65 v “1110 Keyboard bezel” on page 74 In step 1, unplug the jacks by using the removal tool antenna RF connector (P/N: 08K7159) or pick (...)

84 Page 84 of Lenovo THINKPAD T60 - Hardware maintenance manual

Lenovo THINKPAD T60 - Hardware maintenance manual 1130 Wireless WAN (AUX) antenna cable For access, remove these FRUs in order: v “1010 Battery pack” on page 57 v “1040 Palm rest or palm rest with fingerprint reader” on page 61 v “1060 Keyboard” on page 65 v “1110 Keyboard bezel” on page 74 1 1 2 Step Screw (quantity) Color Torque 1 M2 × 3 mm, small-head, nylon-coated (2) Silver 0.167 Nm ( (...)

85 Page 85 of Lenovo THINKPAD T60 - Hardware maintenance manual

Lenovo THINKPAD T60 - Manual 1140 Speaker assembly For access, remove these FRUs in order: v “1010 Battery pack” on page 57 v “1040 Palm rest or palm rest with fingerprint reader” on page 61 v “1060 Keyboard” on page 65 v “1110 Keyboard bezel” on page 74 v “1130 Wireless WAN (AUX) antenna cable” on page 78 The speaker cables are secured with tapes (a). a 1 1 1 a (...)

86 Page 86 of Lenovo THINKPAD T60 - Hardware maintenance manual

THINKPAD T60 - When installing: Make sure that the speaker connector is attached firmly, and the cables are routed as in this figure. 4 3 4 2 2 Removing and replacing a FRU 80 MT 6369, 6370, 6371, 6372, 8741, 8742, 8743, and 8744 (...)

87 Page 87 of Lenovo THINKPAD T60 - Hardware maintenance manual

Lenovo THINKPAD T60 - Desktop, Keyboard Manual 1150 Fan assembly For access, remove these FRUs in order: v “1010 Battery pack” on page 57 v “1040 Palm rest or palm rest with fingerprint reader” on page 61 v “1060 Keyboard” on page 65 v “1110 Keyboard bezel” on page 74 v “1130 Wireless WAN (AUX) antenna cable” on page 78 v “1140 Speaker assembly” on page 79 1 2 3 Step Screw (quanti (...)

88 Page 88 of Lenovo THINKPAD T60 - Hardware maintenance manual

Lenovo THINKPAD T60 - Desktop, Keyboard Manual Attention: Do not handle the fan roughly. Improper handling of the fan can cause distortion or deformation and imperfect contact with components. 4 4 4 5 5 Step Screw (quantity) Color Torque 4 M2 × 9.5 mm, flat-head, nylon-coated (3) Black 0.167 Nm (1.7 kgfcm) In step 5, release the wireless antenna cables from the cable guide of the fan assembly. 6 7 Re (...)

89 Page 89 of Lenovo THINKPAD T60 - Hardware maintenance manual

Lenovo THINKPAD T60 - Desktop, Keyboard Manual When installing: v Before you attach the fan assembly to the computer, apply thermal grease, at an amount of 0.2 grams, on the part marked a as in the following figure. Either too much or too less application of grease can cause a thermal problem due to imperfect contact with a component. a v Make sure that the fan connector is attached firmly. v When attac (...)

90 Page 90 of Lenovo THINKPAD T60 - Hardware maintenance manual

Lenovo THINKPAD T60 - Desktop, Keyboard Manual 1160 CPU For access, remove these FRUs in order: v “1010 Battery pack” on page 57 v “1040 Palm rest or palm rest with fingerprint reader” on page 61 v “1060 Keyboard” on page 65 v “1110 Keyboard bezel” on page 74 v “1130 Wireless WAN (AUX) antenna cable” on page 78 v “1140 Speaker assembly” on page 79 v “1150 Fan assembly” on page (...)

91 Page 91 of Lenovo THINKPAD T60 - Hardware maintenance manual

Lenovo THINKPAD T60 - Manual 1170 SIM card slot For access, remove these FRUs, in order: v “1010 Battery pack” on page 57 v “1040 Palm rest or palm rest with fingerprint reader” on page 61 v “1060 Keyboard” on page 65 v “1110 Keyboard bezel” on page 74 Note: If the SIM card has been inserted in its slot, remove it before you start the servicing. After you finish the servicing (...)

92 Page 92 of Lenovo THINKPAD T60 - Hardware maintenance manual

Lenovo THINKPAD T60 - Desktop, Keyboard Manual 1180 LCD assembly For access, remove these FRUs in order: v “1010 Battery pack” on page 57 v “1040 Palm rest or palm rest with fingerprint reader” on page 61 v “1060 Keyboard” on page 65 v “1080 PCI Express Mini Card for 802.11 a/b/g wireless LAN” on page 69 v “1110 Keyboard bezel” on page 74 v “1120 PCI Express Mini Card for wireless WAN (...)

93 Page 93 of Lenovo THINKPAD T60 - Hardware maintenance manual

THINKPAD T60 - 3 2 4 4 3 Step Screw (quantity) Color Torque 3 M2 × 5 mm, flat-head, nylon-coated (2) Black 0.167 Nm (1.7 kgfcm) In step 4, strip off the tapes securing the antenna cables, and release the cables from the cable guides of the frame. (continued) Removing and replacing a FRU ThinkPad T60 and T60p (15.4-inch widescreen) 87 (...)

94 Page 94 of Lenovo THINKPAD T60 - Hardware maintenance manual

Lenovo THINKPAD T60 - Desktop, Keyboard Manual 5 5 When installing: 1. Route the antenna cables along the cable guides and secure them with the tapes. As you route the cables, make sure that they are not subjected to any tension. Tension could cause the cables to be damaged by the cable guides, or a wire to be broken. 2. Make sure that the LCD connector is attached firmly. Removing and replacing a FRU 88 MT 63 (...)

95 Page 95 of Lenovo THINKPAD T60 - Hardware maintenance manual

Lenovo THINKPAD T60 - Desktop, Keyboard Manual 1190 Base cover and USB sub card with cable For access, remove these FRUs, in order: v “1010 Battery pack” on page 57 v “1040 Palm rest or palm rest with fingerprint reader” on page 61 v “1060 Keyboard” on page 65 v “1080 PCI Express Mini Card for 802.11 a/b/g wireless LAN” on page 69 v “1110 Keyboard bezel” on page 74 v “1120 PCI Express (...)

96 Page 96 of Lenovo THINKPAD T60 - Hardware maintenance manual

THINKPAD T60 - 3 4 4 3 Step Screw (quantity) Color Torque 3 M2 × 9.5 mm, flat-head, nylon-coated (1) Black 0.167 Nm (1.7 kgfcm) 4 M2 × 14 mm, flat-head, nylon-coated (2) Black 0.167 Nm (1.7 kgfcm) 5 6 Step Screw (quantity) Color Torque 5 M2 × 3 mm, small-head, nylon-coated (1) Silver 0.167 Nm (1.7 kgfcm) (continued) Removing and replacing a FRU 90 MT 6369, 6370, 6 (...)

97 Page 97 of Lenovo THINKPAD T60 - Hardware maintenance manual

THINKPAD T60 - Attention: Before step 7, be sure that the Ultrabay Slim device eject lever has not popped out. It must be housed in its position as shown in the figure a. 7 a 8 Remove the USB sub card with cable and the security hole bracket as in this figure. 1 1 2 3 4 Step Screw (quantity) Color Torque 1 M2 × 3.5 mm, flat-head, nylon-coated (2) Black 0.167 Nm (...)

98 Page 98 of Lenovo THINKPAD T60 - Hardware maintenance manual

THINKPAD T60 - Note: Applying labels to the base cover The new base cover FRU is shipped with a kit containing labels of several kinds. When you replace the base cover, you need to apply the following labels: 1 Product label 2 Homologation label Following labels need to be peeled off from the old base cover, and need to be put on the new base cover. 3 Wireless LAN LMA (...)

99 Page 99 of Lenovo THINKPAD T60 - Hardware maintenance manual

Lenovo THINKPAD T60 - Desktop, Keyboard Manual 1200 Structure frame For access, remove these FRUs, in order: v “1010 Battery pack” on page 57 v “1020 Ultrabay Slim device” on page 58 v “1030 Hard disk drive cover, hard disk drive, and hard disk drive rubber rails” on page 59 v “1040 Palm rest or palm rest with fingerprint reader” on page 61 v “1060 Keyboard” on page 65 v “1070 Modem da (...)

100 Page 100 of Lenovo THINKPAD T60 - Hardware maintenance manual

Lenovo THINKPAD T60 - Manual Remove the ac power jack cable a and the modem cable b. 5 2 3 4 4 a b When installing: Make sure the connectors are attached firmly, and that the cables are routed as in the figure above. (continued) Removing and replacing a FRU 94 MT 6369, 6370, 6371, 6372, 8741, 8742, 8743, and 8744 (...)

Related Devices for Lenovo THINKPAD T60 -